1 in 10 U.S. cars and trucks have been recalled

Chevy-Camaro-recall

(Photo: General Motors)

NEW YORK (CNNMoney) — Roughly one out of every 10 of passenger cars and trucks on the road in the U.S. has been recalled this year.

The auto industry has recalled a stunning 25.3 million U.S. vehicles in so far in 2014. That leaves it poised to shatter the record 30.8 million vehicles that were recalled in 2004.

General Motors prompted the surge when it revealed that it took ten years to issue a recall for a flawed ignition switch that’s been tied to at least 13 deaths.

In the wake of those revelations, GM has changed its procedures and recalled a total of 14.4 million U.S. vehicles in 2014 — a record for the company. The latest announcement came Friday morning, when GM recalled another 512,000 Camaros. Other automakers have also issued a raft of recalls, scared that they, too, could be accused of overlooking safety problems.

The recalls have been for flaws as serious as a steering problem that prompted GM to tell owners of 477 pickups and SUVs to stop driving their vehicles immediately — GM sent flatbed trucks to haul the vehicles to dealerships for repairs.

They’ve also been for matters as minor as a sticker on the inside of some Kias that incorrectly stated the recommended tire pressure. Kia sent out new labels.

There were 252.7 million passenger vehicles in operation in the U.S. at the start of this year, according to IHS Automotive, meaning the total number of recalls is roughly 10% of the nation’s fleet of cars and trucks.

If there isn’t another recall the rest of this year, 2014 will rank as the third largest number of U.S. recalls in history.

But there is no sign of a slowdown. GM’s recall crisis has triggered both congressional and criminal probes, and the automaker must pay a $35 million fine to the National Highway Traffic Safety Administration (NHTSA). GM has said it will cost at least $1.7 billion to repair the recalled cars, and it may have to pay out billions to crash victims and their families. No other automaker wants to risk a similar fate.

“On recall issues, you’re going to see a heightened level of sensitivity. You may see excessive corrective actions,” said Fiat Chrysler CEO Sergio Marchionne at a forum last month. He later told CNBC, “There’s no doubt that the industry is going to have to adjust to a new paradigm. This is permanent.”

Clarence Ditlow, executive director of the Center for Auto Safety, said that he believes as many as 35 million cars could be recalled this year, but that he thinks the pace of recalls will slow down.

“Part of what [automakers] are doing is going through the backlog of vehicles they should have recalled in the past and didn’t,” he said. “Once they get through that backlog, it’ll be new recalls only.”

Many of the vehicles recalled this year are older models. GM says that 70% of the autos it has recalled in the U.S. this year are models it no longer manufactures.

Ditlow said the negative press surrounding the GM recall crisis has changed the dynamics among automaker employees who examine accident reports and consumer complaints, making it easier for someone who believes a recall is necessary to prevail.

He said GM’s move to ax 15 employees who failed to act appropriately with regard to the ignition switch recall will also prompt employees to be more aggressive on recalls. In the past, engineers or lawyers had little to fear in terms of their job security, he said.

“To think you could get fired if you don’t pursue safety, that is a change,” he said.

GM recalls 512,000 Camaros

General Motors announced a new recall of 512,000 Camaros, saying a flaw can switch the popular sports car off while it’s being driven.

GM said that the problem is similar but not identical to the flawed ignition switch in 2.6 million Chevrolet Cobalts that has been tied to at least 13 deaths. In that recall, the ignition switch itself was faulty and needed to be replaced. In the case of the Camaro, the design of the ignition key and the attached fob makes it susceptible to being bumped out of the “run” position, similar to what happened with the recalled Cobalts.

But GM said the ignition switch does not need to be replaced in the Camaro. Instead it is issuing a new key and fob which aren’t attached to each other.

GM said the problem with the Camaro has been traced to at least three accidents and four minor injuries, but no deaths or serious injuries.

GM said that it is acting much faster in response to reports of problems than it did with the Cobalts, which the automaker waited 10 years to recall.

“Discovering and acting on this issue quickly is an example of the new norm for product safety at GM,” said Jeff Boyer, vice president of GM Global Safety.

GM is under fire over the 10-year delay in the Cobalt recall. It had to pay the maximum $35 million fine to federal safety regulators and faces criminal probes as well as Congressional investigations over that recall. The automaker has also said it will set up a fund to compensate those crash victims.

The Camaro recall covers the models years from 2010 through the current 2014 model. The company said it applies to 465,000 Camaros in the United States, while the rest are in Mexico, Canada or overseas.

GM also announced three other minor recalls in which there were no accidents or injuries reported, including about 30,000 Saab convertibles due to a problem with the seat belt retractor. Saab, which GM jettisoned as part of its 2009 bankruptcy, is one of the few GM brands that the automaker had not recalled before now.

GM is also recalling 25,000 Chevy Sonics, and 15,000 Buick LaCrosses.

All told, Friday’s recall brings GM’s recall total for the year to 14.4 million U.S. cars and trucks, and 16.5 million worldwide.

™ & © 2014 Cable News Network, Inc., a Time Warner Company. All rights reserved.

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out / Change )

Twitter picture

You are commenting using your Twitter account. Log Out / Change )

Facebook photo

You are commenting using your Facebook account. Log Out / Change )

Google+ photo

You are commenting using your Google+ account. Log Out / Change )

Connecting to %s